01 November 2010

Choosing a transistor- selection criterion

Choosing a suitable NPN transistor

The circuit diagram shows how to connect an NPN transistor, this will switch on the load when the chip output is high. If you need the opposite action, with the load switched on when the chip output is low (0V)
The procedure below explains how to choose a suitable switching transistor.


  1. The transistor's maximum collector current Ic(max) must be greater than the load current Ic.
    load current Ic =   supply voltage Vs
    load resistance RL
  2. The transistor's minimum current gain hFE(min) must be at least five times the load current Ic divided by the maximum output current from the chip.
    hFE(min)  >   5 ×     load current Ic  
    max. chip current
  3. Choose a transistor which meets these requirements and make a note of its properties: Ic(max) and hFE(min).

  4. Calculate an approximate value for the base resistor:
    RB =   Vc × hFE    where Vc = chip supply voltage
      (in a simple circuit with one supply this is Vs)
    5 × Ic
    For a simple circuit where the chip and the load share the same power supply (Vc = Vs) you may prefer to use: RB = 0.2 × RL × hFE Then choose the nearest standard value for the base resistor.
  5. Finally, remember that if the load is a motor or relay coil a protection diode is required.
Example
The output from a 4000 series CMOS chip is required to operate a relay with a 100ohm coil.
The supply voltage is 6V for both the chip and load. The chip can supply a maximum current of 5mA.

  1. Load current = Vs/RL = 6/100 = 0.06A = 60mA, so transistor must have Ic(max) > 60mA.
  2. The maximum current from the chip is 5mA, so transistor must have hFE(min) > 60 (5 × 60mA/5mA).
  3. Choose general purpose low power transistor BC182 with Ic(max) = 100mA and hFE(min) = 100.
  4. RB = 0.2 × RL × hFE = 0.2 × 100 × 100 = 2000ohm. so choose RB = 1k8 or 2k2.
  5. The relay coil requires a protection diode.





Choosing a suitable PNP transistor

The circuit diagram shows how to connect a PNP transistor, this will switch on the load when the chip output is low (0V). If you need the opposite action, with the load switched on when the chip output is high
The procedure for choosing a suitable PNP transistor is exactly the same as that for an NPN transistor described above.


10 comments:

Anonymous said...

Hmm it appears like your website ate my first comment (it was super long) so I guess I'll just sum it up what I wrote and say, I'm thoroughly enjoying your blog.
I as well am an aspiring blog blogger but I'm still new to everything. Do you have any helpful hints for first-time blog writers? I'd genuinely appreciate it.


Stop by my blog :: computer components wholesale nz

Anonymous said...

Howdy admin, I just wanted to give you a brief heads up that
your Website url: http://www.blogger.com/comment.
g?blogID=6274980547637186007&postID=11020359252567938 is being flagged
as a potentially harmful web site in my web browser
ie. I would highly recommend having someone look into it.
You can lose a lot of guests due to this kind of issue.
Best of Luck.

Feel free to visit my weblog ... toshiba portege r835-p88

Anonymous said...

First off I would like to say wonderful blog!

I had a quick question in which I'd like to ask if you do not mind. I was curious to know how you center yourself and clear your mind prior to writing. I've had
a tough time clearing my mind in getting my thoughts out.
I truly do enjoy writing however it just seems like the first
10 to 15 minutes are wasted simply just trying to figure out
how to begin. Any ideas or hints? Cheers!

my web-site; all computer components and their functions

Anonymous said...

Hey there just wanted to give you a brief heads
up and let you know a few of the images aren't loading properly. I'm not sure why but I think its a linking issue.

I've tried it in two different web browsers and both show the same results.

my web page: toshiba satellite laptop charger

Anonymous said...

Howdy! It looks as though we both have a passion for the same thing.
Your blog, "Blogger: Rough Record" and mine are very similar.
Have you ever thought about authoring a guest write-up for a similar website?
It will definitely help gain exposure to your blog (my site recieves a lot
of visitors). If you happen to be interested, email me at: rickie-brothers@fastmail.
fm. Thanks

Also visit my web blog; exercise equipment for home cheap

Anonymous said...

Hi there would you mind letting me know which web host you're using? I've
loaded your blog in 3 completely different web browsers and I
must say this blog loads a lot faster then most. Can you recommend a good hosting provider at a reasonable price?

Thanks a lot, I appreciate it!

my webpage; fitness tumblr for women

Anonymous said...

I am curious to find out what blog system you happen to be using?

I'm having some small security problems with my latest website and I would like to find something more risk-free. Do you have any suggestions?

Feel free to surf to my weblog; rahpouyan.eu
my web site :: gymnastics clothes for girls

Anonymous said...

Hello! This is kind of off topic but I need
some guidance from an established blog. Is it
hard to set up your own blog? I'm not very techincal but I can figure things out pretty quick. I'm thinking
about setting up my own but I'm not sure where to start. Do you have any ideas or suggestions? Thank you

Look at my web site: misty contact circuit board cleaner
Also see my web site: discount computer parts tucson

Anonymous said...

Hi. I'm wondering if you'd be interested in doing a link swap?

I notice your blog: http://www.blogger.com/comment.

g?blogID=6274980547637186007&postID=11020359252567938 and my blog are based mostly around the
same topic. I'd really like to switch links or possibly guest author a write-up for you. Here is my personal e-mail: salliealbrecht@t-online.de. I highly recommend you contact me if you're even slightly interested.
Thanks.

Also visit my webpage ... circuit board kits for beginners

Naviya Nair said...

I have read your blog its very attractive and impressive. I like it your blog.

Java Online Training Java EE Online Training Java EE Online Training Java 8 online training Core Java 8 online training

Java Online Training from India Java Online Training from India Core Java Training Online Core Java Training Online Java Training InstitutesJava Training Institutes

Post a Comment

Related Posts with Thumbnails

Popular Posts

 
;